The search result changed since you submitted your search request. Documents might be displayed in a different sort order.
  • search hit 503 of 543
Back to Result List

Non-Esterified Plant Oils as Fuel -Engine Charakteristics, Emission and Mutagenic effects of PM-

  • Plant oils may be used as a sustainable, nearly CO2 neutral fuel for diesel engines. This work investigates experimentally the particulate and gaseous emissions of diesel engines fuelled with non-esterified, pure plant oils with the quality standard of DIN V 51605 (Weihen-stephan RK-Qualitätsstandard 05/2000). The data are collected from three engines: Common rail passenger car engine fromPlant oils may be used as a sustainable, nearly CO2 neutral fuel for diesel engines. This work investigates experimentally the particulate and gaseous emissions of diesel engines fuelled with non-esterified, pure plant oils with the quality standard of DIN V 51605 (Weihen-stephan RK-Qualitätsstandard 05/2000). The data are collected from three engines: Common rail passenger car engine from OPEL AG Truck engine from VOLVO Truck engine from MAN AG All engines have been correctly adjusted to plant oil operation. The OPEL and VOLVO engines served for the basic investigations. The emissions of the MAN engine have been used to perform AMES tests to analyze possible health impacts of plant oil operation. The experimental data show a reduction of particulate matter compared to traditional gasoil which may yield up to 50 % for. The particulate matter shows same primary particle sizes but the agglomerates as collected on TEM grids are different - the plant oil soot particles tend to form larger aggregates [4]. The gaseous emissions of CO and hydrocarbons HC are generally lower compared to the operation with gasoil. However, the NOX emissions are slightly higher. This may be contributed to the measured higher combustion chamber pressures and temperatures when fuelled by plant oils. Emission samples have been extracted from ESC cycles of 13 step tests to perform the AMES test which give indication on carcinogen substances. The AMES test results gave no indication of mutagenic effects exceeding the detection limits. No significant differences could be found comparing the emissions of plant oil and gasoil operation. Thus, it can be stated that the emission from plant oil operation does not have a health impact different to traditional gas oil. This is in contrast to some other publications — a deeper insight shows that these investigations did not properly modify the engine for plant oils. It is mandatory to make the engine modification to pre-warm the plant oils to approx. 90°C prior to injection. The engine's warm-up phase needs special care to avoid any coking at the injection system and combustion chamber surfaces. The publications where a higher health risk was claimed to be found in the exhaust of plant oil fuels, did not pre-warm the plant oils — cold plant oils have been injected in the combustion chamber instead. This results in incomplete atomization and incomplete combustion with a lot of hazardous emission species (see also [4,11]. Such an operation will damage the engine after relatively short times and is, therefore, not realistic. The investigated fuels had some influence on the engine characteristics. Higher temperatures and pressures in the cylinder have been detected for some plant oils compared to gasoil. This increase is explained by the higher oxygen content within the plant oils.show moreshow less

Export metadata

Additional Services

Share in Twitter Search Google Scholar
Metadaten
Author:Benjamin Dorn, Richard A. ZahoranskyGND
Creating Corporation:Society of Automotive Engineers / Naples Section
Publisher:SAE International
Place of publication:Warrendale, Pa.
Date of Publication (online):2009/09/13
Language:English
Parent Title (English):SAE: Technical Papers
Volume:2009
ISSN:0148-7191
ISSN:2688-3627 (e-ISSN)
First Page:2009-24-0097
Document Type:Conference Proceeding
Institutes:Hochschule Offenburg / Bibliografie
Acces Right:Zugriffsbeschränkt
Release Date:2014/12/05
Licence (German):License LogoEs gilt das UrhG
Note:
9th International Conference on Engines and Vehicles : ICE 2009 ; September 13 - 18, 2009, Capri, Naples, Italy ; [papers]
DOI:https://doi.org/10.4271/2009-24-0097